Product ID:GACOFLEX N-1111
MSDS Date:06/19/1986
FSC:8010
NIIN:00N012281
MSDS Number: BJRZP

GACO WESTERN INC

18700 S CENTER PARKWAY
SEATTLE, WA 98188-4636
US

Emergency Phone: 206-575-0450

Info Phone: 206-575-0450

Cage: 09463

GACO WESTERN INC

88698 SEATTLE, WA 98188-4636 US

Telephone: 206-575-0450

Cage: 09463

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 12.84%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ISOBUTYL ACETATE (SARA III)

CAS: 110-19-0

RTECS: AI4025000

Fraction By Weight: 25.32%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ALIPHATIC NAPHTHA. VP = 15 MMHG @ 37.7C

Fraction By Weight: 22.28%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: HIGH CONCENTRATIONS CAN PRODUCE
CNS DEPRESS. SKIN: CAN CAUSE SEVERE IRRITATION, POSSIBLY BURNS,
DEFATTING AND DERMATITIS. EYE: CAUSES SEVERE IRRITATION, REDNESS,
TEARING AND BLURRED VISION. MFR IDENTIFIES SKIN AS A PRIMARY ROUTE
OF ENTRY. CHRONIC: RPTD EXPOS CAN CAUSE ALLERGIC RESP RXN (SEE EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: W/DEVELOPMENT OF OCCUPATIONAL ASTHMA.
LONG TERM RPTD EXPOS TO LOW VAP CONC MAY CAUSE CHRONICALLY
PROGRESSIVE PULM DISEASE. RPTD SKIN CONT CAN RESULT IN SENSIT.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL: IF OVERCOME BY VAPS, REMOVE TO FRESH AIR AND IF
BREATHING HAS STOPPED, GIVE ARTF RESP. GET MD IMMED. INGEST: DO NOT
INDUCE VOMITING DUE TO HAZARD OF SOLVENT ASPIRATION AND SUBSEQUENT
CHEMICAL P NEUMONITIS. EYE: FLUSH WITH WATER FOR AT LEAST 15
MINUTES.

Flash Point:25.0F,-3.9C
Lower Limits:0.9
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
USE WATER SPRAY TO COOL FIRE EXPOS SURF & PROTECT PERS. WHEN USING
WATER SPRAY, BOIL OVER (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:DO NOT STORE/MIX W/STRONG OXIDANTS.
CARBON MONOXIDE EVOLVED IF COMB INCOMPLETE. LEAKS OF GAS/SPILLS OF
LIQ CAN READILY FORM FLAM MIX AT TEMPS AT/> FLASH POINT.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT. KEEP PEOPLE AWAY.
RECOVER FREE LIQ. ADD ABSORBENT TO SPILL AREA. AVOID BRTHG VAPS,
VENT ENCLOSED SPACES. FLUSH W/LARGE VOLUMES OF WATER. KEEP OUT OF
STREAMS AND WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM OXIDIZING MATLS IN A
COOL, DRY PLACE W/ADEQ EXPLOSION PROOF VENT. KEEP AWAY FROM HEAT,
SPARKS, AND OPEN FLAMES. (SEE OTHER PREC)
Other Precautions:HNDLG/STOR PREC:GROUND HANDLING EQUIPMENT TO PREVENT
ACCUMULATION OF STATIC CHARGE. KEEP CONTAINERS TIGHTLY SEALED.
DANGER. HARMFUL OR FATAL IF SWALLOWED. FLAMMABLE VAP HARMFUL. MAY
CAUSE SKIN OR EYE IRRIT. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:SPRAY: NIOSH/MSHA APPROVED ORGANIC VAPOR
RESPIRATOR. HIGH VAPOR CONCENTRATIONS: SCBA.
Ventilation:EXPLOSIVE PROOF MECHANICAL EQUIPMENT ADEQUATE TO KEEP
CONCENTRATIONS BELOW TLV.
Protective Gloves:RUBBER GLOVES.
Eye Protection:CHEM WORK GOGGLES/FACESHLD OPTNL .
Other Protective Equipment:EYE BATH, SAFETY SHOWER RECOMMENDED.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE EATING, DRINKING,
SMOKING, USING TOILET FACILITIES. LAUNDER CONTAMD CLTHG BEFORE
REUSE.
Supplemental Safety and Health
FIRE FIGHT PROC: MAY OCCUR WHEN FINAL BOILING POINT OF SOLV APPROACHES
THAT OF WATER. DO NOT EXTING FLAME AT LEAK BECAUSE POSSIBILITY OF
UNCONTROLLED EXPLO REIGNITION EXISTS. CUT OFF FUEL AND/OR ALLOW
FIRE TO BURN OUT. EXTING SMALL RESIDUAL FIRES W/CHEM POWDER/WATER
SPRAY. TRY TO COVER LIQ SPILLS W/FOAM.

HCC:F3
Boiling Pt:B.P. Text:>100F,>38C
Vapor Pres:SEE INGRED
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:80.5

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, AND OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE EVOLVED IF COMBUSTION
INCOMPLETE.

Waste Disposal Methods:CONTAIN SPILLED LIQUID WITH SAND OR EARTH.
DISPOSE IN APPROVED DUMPING AREA. CONTAINERS MUST BE SEALED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.